Product ID:Z AEROSOL
MSDS Date:07/17/1992
FSC:8030
NIIN:00N042999
MSDS Number: BSYSG

ITW DEVCON

30 ENDICOTT ST
DANVERS, MA 01923
US

Emergency Phone: 800-424-9300(CHEMTREC)

Info Phone: 508-777-1100

Cage: 0RZG3

ITW DEVCON

DANVERS, MA 01923-3712 US

Telephone: 978-777-1100

Cage: 0RZG3

2.3%

CAS: 74-98-6

RTECS: TX2275000

Fraction By Weight: 10-30%

OSHA PEL 1000 PPM

ACGIH TLV: SIMPE ASPHYXIANT

1.0%

CAS: 1330-20-7

RTECS: ZE2100000

Fraction By Weight: 10-30%

OSHA PEL 100 PPM;150 PPM STEL

ACGIH TLV: 100 PPM;150 PPM STEL

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

SOLVENT NAPHTHA (PETROLEUM) MEDIUM ALIPHATIC; (MEDIUM

CAS: 64742-88-7

Fraction By Weight: 5-10%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM

STODDARD SOLVENT; (MINERAL SPIRIT)

CAS: 8052-41-3

RTECS: WJ8925000

Fraction By Weight: 1-5%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM

BENZENE, ETHYL-; (ETHYL BENZENE)

CAS: 100-41-4

RTECS: DA0700000

Fraction By Weight: 1-5%

OSHA PEL 100 PPM;125 PPM STEL

ACGIH TLV: 100 PPM;125 PPM STEL

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

9.8 LBS/GAL

RTECS: 9999999VO

OSHA PEL N/K

ACGIH TLV: N/K

LD50 LC50 Mixture:LD50:(ORAL,RAT)5200 MG/KG (XYLENE)
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES: SLIGHT IRRIT. SKIN: MAY
CAUSE SLIGHT IRRIT/DERM. INHAL: MILDLY IRRITATING TO MUC MEMB.
HIGHER CONC CAN CAUSE DIZZ, DROW, DISORIENTATION. INGEST: MAY CAUSE
VOMIT. (DRAWING OF VOMIT INTO LU NGS CAN CAUSE SEV DANGEROUS CHEM
PNEUM WITH GASPING BLUISH SKIN). CHRONIC: PRLNGD/RPTD EXPOS CAN
CAUSE (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: NEURAL DYSFUNCTION W/DIZZ, DROW, A
LOSS OF COORD. NOTE: INHAL OF HIGH CON CAN CAUSE UNCON & DEATH.
INGEST OF LG QTY CAN CAUSE CONVULS & DEATH.
Medical Cond Aggravated by Exposure:INHALATION OF SOLVENTS MAY
AGGRAVATE EXISTING RESPIRATORY DISORDERS.

First Aid:EYES: FLUSH FOR AT LEAST 15 MINUTES WITH WATER AND CONTACT A
PHYSICIAN. SKIN: WASH WITH PLENTY OF SOAP AND WATER. INHAL: REMOVE
TO FRESH AIR. ADMINISTER OXYGEN IF BREATHING IS DIFFICULT. GET MED
ATTN. INGEST: DO NOT INDUCE VOMIT. CONTACT APHYS. IF VOMIT OCCURS,
KEEP HEAD BELOW HIPS TO PREVENT DRAINING OF VOMITUS INTO LUNG.

Flash Point:SUPP DATA
Lower Limits:SEE ING
Upper Limits:SEE ING
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:PRIMARILY THOSE NORMALLY ASSOCIATED WITH
AEROSOL CONTAINERS. HANDLE AS A COMBUSTIBLE MATERIAL.

Spill Release Procedures:ELIMINATE ALL SOURCES OF IGNITION. PROVIDE
ADEQUATE VENTILATION. ABSORB WITH SWEEPING COMPOUND.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:AVOID OPEN FLAME, SPARKS & EXCESSIVE
HEAT. USE W/ADEQ VENT. AVOID PRLNGD/RPTD PERSONAL CONTACT. STORE IN
A COOL, DRY PLACE. AVOID SPLASHING.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.

Respiratory Protection:NO RESP PROT NEEDED FOR NORM USE W/GOOD VENT. IF
NOT, USE NIOSH/MSHA APPRVD ORG VAP RESP (FOR VAP CONC TO 1000PPM)
OR NIOSH/ MSHA APPROVED AIR-PURIFYING RESP IN VERY CONFINED AREAS.
Ventilation:GEN MECH SHOULD BE SUFFICIENT FOR NORM USE IN OPEN AREAS.
IN CONFINED AREAS, LOC EXHAUST MAY BE NEC TO KEEP (SUPP DATA)
Protective Gloves:RUBBER GLOVES.
Eye Protection:ANSI APPRVD CHEM SAFETY GOGGLES .
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
VP: 70PSIA (PROPANE). FL PT: 156F,69C (PROPANE). VENT: VAPOR CONC BELOW
TLV'S.

HCC:V3
Boiling Pt:B.P. Text:44F,6.7C
Vapor Pres:SUPP DATA
Vapor Density:>1
Spec Gravity:1.95
pH:7
Evaporation Rate & Reference:>1(BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:GRAY OPAQUE LIQUID WITH ODOR
Percent Volatiles by Volume:40

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, ACIDS AND BASES.
Stability Condition to Avoid:HEAT, SPARKS AND OPEN FLAMES.
Hazardous Decomposition Products:OXIDES OF CARBON.

Waste Disposal Methods:CONTAINS RCRA-LISTED HAZARDOUS WASTE MATERIALS.
DISPOSE OF AS COMBUSTIBLE WASTE I/A/W LOCAL, STATE AND FEDERAL
REGULATIONS. APPLIC CERCLA/RCRA HAZ WASTE CODES: V239 (XYLENE).
REPORTABLE QTY UNDER CERC LA, IN POUNDS: 100.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.